Search found 874 matches

by rallyak
Thu Mar 14, 2019 4:44 pm
Forum: Body, Chassis and Interior
Topic: Bumper material
Replies: 1
Views: 132

Re: Bumper material

Yes its weldable, the bumper on my wife’s 92 was busted pretty bad. About a 8 inch crack on each side, not sure what plastic it is but stainless mesh wire on both sides with uniweld ribbon is the way I fixed mine.
by rallyak
Tue Feb 12, 2019 6:43 am
Forum: Intake
Topic: 91 MT IAC?
Replies: 5
Views: 317

Re: 91 MT IAC?

Yes, the injectors are different but air/fuel is still on the rich side even though the gray ones are smaller. In my car I’ve cleaned the IACV hundreds of times along with the two small springs and the solenoid on the top. I have a few laying around and tried three different ones and never seem to w...
by rallyak
Mon Feb 11, 2019 7:58 am
Forum: Intake
Topic: 91 MT IAC?
Replies: 5
Views: 317

Re: 91 MT IAC?

I too have a 90 MT with the same IAC and I did what your thinking of doing. I changed the ECM from a 93 legacy, the IAC and the MAF to match. All my idle issues went away and runs like a different car. I should have done it years ago. I didn’t have any issues with wiring it was completely plug and p...
by rallyak
Sat Sep 29, 2018 7:59 pm
Forum: Drivetrain
Topic: rear axle difference
Replies: 6
Views: 799

Re: rear axle difference

I knew 91 was special in the VLSD I though it was the axles, didn’t think about the stubs.
by rallyak
Sat Sep 29, 2018 7:51 pm
Forum: Drivetrain
Topic: rear axle difference
Replies: 6
Views: 799

Re: rear axle difference

91 turbo has different axles because of the locking diff. I believe all others are the same from 89-94.
by rallyak
Fri Aug 31, 2018 7:06 am
Forum: Exhaust
Topic: 02 Sensor Help?!
Replies: 1
Views: 836

Re: 02 Sensor Help?!

91 only has one 02 sensor
by rallyak
Fri Mar 23, 2018 3:58 pm
Forum: Misc
Topic: Help with 91 Legacy Postal(RHD) wagon heater core
Replies: 5
Views: 1325

Re: Help with 91 Legacy Postal(RHD) wagon heater core

Just curious, it the thermostat OEM or aftermarket?
by rallyak
Thu Feb 22, 2018 6:23 am
Forum: Engine
Topic: ...car won't start [help]
Replies: 12
Views: 1512

Re: ...car won't start [help]

Do you here the fuel pump when you turn the key on?
by rallyak
Sun Feb 04, 2018 8:08 pm
Forum: Engine
Topic: Ej22t rebuild. Intake valves being held open?
Replies: 5
Views: 1034

Re: Ej22t rebuild. Intake valves being held open?

It sound like the HLA’s are just fully pumped up, they should bleed off when you start it.
by rallyak
Sun Dec 17, 2017 11:18 pm
Forum: Picture and Multimedia Gallery
Topic: rallyak car's and journeys
Replies: 132
Views: 24365

Re: rallyak car's and journeys

Ordered it from Ralli spec, apparently was fitted in version 5/6 STI RA 5 speeds.
http://www.rallispec.com/dif_gls_rst1903.html
by rallyak
Sun Dec 17, 2017 7:44 pm
Forum: Picture and Multimedia Gallery
Topic: rallyak car's and journeys
Replies: 132
Views: 24365

Re: rallyak car's and journeys

I am still using photobucket but the pictures that wasn’t working I placed them in a different file then I was able to copy and paste back on to the thread. It’s weird that not all the pictures were shut down but about 90% were. Some of the sites shows that they sell the OBX diff but can’t get them....
by rallyak
Sun Dec 17, 2017 1:45 am
Forum: Picture and Multimedia Gallery
Topic: rallyak car's and journeys
Replies: 132
Views: 24365

Re: rallyak car's and journeys

No, I didn’t replace the washers when I installed it, and would of bought a new one but there no longer available so I called Ralli spec and ordered the oem unit from Japan. This is the one I ordered: http://www.rallispec.com/dif_gls_rst1903.html Little expensive but I’m sure it’s a quality unit. Yo...
by rallyak
Sat Dec 16, 2017 11:58 pm
Forum: Picture and Multimedia Gallery
Topic: rallyak car's and journeys
Replies: 132
Views: 24365

Re: rallyak car's and journeys

Hi everyone, I was restoring all the pictures on my pages and figured I would do an update. My 90 the transmission was making noise so I removed it,and this the one with the OBX front diff. It lasted about 120k and the diff was started coming apart. The input bearings were all shot and pounded the t...
by rallyak
Thu Dec 14, 2017 9:56 pm
Forum: Body, Chassis and Interior
Topic: Air control unit broken and can't find replacement
Replies: 5
Views: 1098

Re: Air control unit broken and can't find replacement

I would check the solder joints on the back of the hvac controller, 90-91s are notorious for solder cracks and all you need to do is touch them with a iron. Here’s a link: https://bbs.legacycentral.org/viewtopic.php?f=10&t=1142 And one more: https://bbs.legacycentral.org/viewtopic.php?f=10&t=1142&st...
by rallyak
Fri Jun 30, 2017 2:49 pm
Forum: Engine
Topic: Oil pan gasket - replace without pulling engine?
Replies: 4
Views: 540

Re: Oil pan gasket - replace without pulling engine?

I've pulled the pan before in the car. I needed to loosen one of the rods to rotate the engine so I can remove the flex plate nuts. The car was free and I needed a 4eats.
by rallyak
Wed May 03, 2017 1:11 am
Forum: Body, Chassis and Interior
Topic: The wipers on my Soob go smack, smack smack...
Replies: 19
Views: 3718

Re: The wipers on my Soob go smack, smack smack...

This is and old thread, but in my case the plastic clips that hold the wiper linkage together was badly worn. I was parting another car out and changed the all the wiper linkage with good clips and wipers are tight now.
by rallyak
Wed Apr 12, 2017 3:48 pm
Forum: Body, Chassis and Interior
Topic: Interior Panel Swaps Pre vs. Post-facelift
Replies: 11
Views: 1452

Re: Interior Panel Swaps Pre vs. Post-facelift

I wasn't aware they moved the abs computer from under the seat in 93. I assumed it was the SRS computer for the airbags.
by rallyak
Mon Apr 10, 2017 5:16 pm
Forum: Body, Chassis and Interior
Topic: Interior Panel Swaps Pre vs. Post-facelift
Replies: 11
Views: 1452

Re: Interior Panel Swaps Pre vs. Post-facelift

Josh, I'm confused? What does ABS have to do with interchangeably of the panels? I know the SRS cars need the correct console to cover the computer.
by rallyak
Sat Apr 08, 2017 5:15 pm
Forum: Body, Chassis and Interior
Topic: Interior Panel Swaps Pre vs. Post-facelift
Replies: 11
Views: 1452

Re: Interior Panel Swaps Pre vs. Post-facelift

Yes, seats, door panels, and interior panels are interchangeable from 90-94. Only few changes from 90-91 to 92-94. Few examples, console opens to the side on 90-91 (I prefer) but 92-94 open from the front and seam to get broke easier. One other is I like the tray in the lower trim under the steering...
by rallyak
Sat Mar 25, 2017 4:29 pm
Forum: Picture and Multimedia Gallery
Topic: rallyak car's and journeys
Replies: 132
Views: 24365

Re: rallyak car's and journeys

Haven't updated in awhile, but on daily checking the new posts. Well last summer went well with hauling asphalt and payed off all my equipment, so this year I might be starting earlier. The truck is dug out and ready to go when ever I get the call. My subie still running and hit 670k last week. The ...
by rallyak
Sat Mar 18, 2017 4:41 pm
Forum: Engine
Topic: Which IACV? HELP
Replies: 1
Views: 368

Re: Which IACV? HELP

Match the one with your car if you have a 5 speed. If you have 4eats I believe that the IAC should be the same.
by rallyak
Wed Mar 01, 2017 5:30 am
Forum: Engine
Topic: EJ25D Crank pulley...anything magic about it?
Replies: 2
Views: 411

Re: EJ25D Crank pulley...anything magic about it?

It's basically a pulley with a zero balance, any 2.2 or 2.5 pulley will work. I went on eBay and bought a lightweight one for mine like this one http://m.ebay.com/itm/VMS-Racing-Light-Weight-Aluminum-Crankshaft-Crank-Pulley-Subaru-Impreza-WRX-Sti-/310958859985?nav=WATCHING_ACTIVE This is what is goi...
by rallyak
Mon Feb 20, 2017 4:47 am
Forum: Electrical
Topic: Power Window Circuit Breaker
Replies: 4
Views: 506

Re: Power Window Circuit Breaker

Under the carpet under drivers seat, and it auto resets.

64-1 is the diagram you want to look at. (Diagram courtesy of josh)
http://www.surrealmirage.com/subaru/fil ... tion04.jpg
by rallyak
Fri Jan 27, 2017 5:25 pm
Forum: Engine
Topic: The wife just said her gas pedal stuck a few times
Replies: 3
Views: 468

Re: The wife just said her gas pedal stuck a few times

I've done that but didn't help, hope you have better results.