Page 1 of 1
Potential fuel leak problem all BC-BF owners
Posted: Mon Sep 08, 2003 3:56 pm
by nubs
Just wanted to let everbody know about the fuel leak that I found on my car. The fuel fill pipe has a plastic guard around it.
Over time this collects a major amount of road debris in it which makes the filler pipe rust through.Mine was through right at the bottom of the guard. I would advise all of you to either take the plastic cover off and clean everthing out befoere it rusts through.
I fixed mine temporarily with some gas tank repair, but plan on putting in a new fill tube at a cost of around $150.00. That is unless I can find a used one in good condition.

Posted: Mon Sep 08, 2003 4:26 pm
by stant093
wow..i just found my leak last week in the exact same spot....i pulled the plastic cover off, claeaned the area up and sprayed some under coating on it, didnt help any...duh

...i was not sure where the leak was coming from, but it seems like the same spot....everytime i put in gas it leaks untill that filler tube is empty, then no more leak....that should be a recall

Posted: Mon Sep 08, 2003 6:24 pm
by JasonGrahn
Thats really interesting. I've got tomorrow off, i may take a look.
If this has happens with multiple cars, it should be brought to SOAs attention.
Even if they attribute it to wear and tear, the techs should be on the lookout for this potential leak.
Posted: Mon Sep 08, 2003 6:51 pm
by vrg3
The fuel filler throat is a common place in general for fuel leaks to happen due to rust. I've seen a lot of cars and trucks 10 or more years of age with this leak.
Posted: Mon Sep 08, 2003 11:49 pm
by Legacy777
I have a buddy with a 95 that had his filler neck rust out
Posted: Fri Feb 24, 2006 6:14 pm
by jmaziarz
My 93' Legacy sprung a leak due to this exact problem a few months ago. I temporarily patched the pinhole sized leak with gas tank repair putty. It has since started to leak again. I'll be replacing the filler pipe with a very nice used one from Blackbart!

Posted: Fri Feb 24, 2006 7:07 pm
by magicmike
hum, could this explain the car smelling like fuel after a fill up and then the smell going away after a short while?
Posted: Fri Feb 24, 2006 7:15 pm
by jmaziarz
I don't smell fuel inside the car but outside is another story. I have found that a quick fix to slow the leak is to break the vacuum by losening gas cap when parking the car. It still leaks but in drips instead of a pressurized stream.
Posted: Sat Feb 25, 2006 5:05 am
by vrg3
Mike - Yeah, it could.
Posted: Sun Feb 26, 2006 6:14 am
by kidatari
Does anyone have the P/N for the replacement fill tube?
Posted: Sun Feb 26, 2006 9:11 am
by kleinkid
When I did my strut/spring changeout I noticed that area was packed full of dirt. Took that cover off and must have chipped out ten pounds of packed in dried mud. Looking at it, I knew it couldn't be doing anything good to that pipe, but never thought about it causing a leak. Glad now I took the time to clean it out.
Posted: Mon Feb 27, 2006 9:09 pm
by 0perose
I was under the car one night looking at what I'd need to do to cut out the spare tire well from under the floor of the wagon.. and noticed this same thing... it was after going down a lot of trails that had a lot of mud and a lot of slush.... and yeah it was packed right full
I thought I made a post just like this when it happened?
Posted: Fri Mar 10, 2006 11:38 pm
by mhrallyteam
Mine leaks bad, 177$ can at the dealer
Posted: Thu Mar 16, 2006 2:23 am
by realfinn
This is not an uncommon problem with ANY car thats driven in rough weather conditions. When you buy a new one from the dealer coat it with por15 (
www.por15.com) it won't happen again. I use the stuff on all of my car restorations and colision repair. It goes on and feels like glass after it dries. It acts as a rust inhibitor. They sold a starter kit for a while that will be more than enough to coat the filler tube (and probably the whole gas tank if you feel ambitious). I think the starter kits are around $20. Believe me its worth it especially after you see how much a new filler costs!
Don't screw around with that cheap ass undercoat crap. Undercoat works but it doesn't last.
Posted: Sun Nov 25, 2007 7:16 am
by greg donovan
wow, i really hope this is what is wrong with my car.
it is leaking a lot. it only makes it to the ground when it is full but will loose 1/4 tank over night.
i am at 56 miles on half a tank right now.
Posted: Tue Nov 27, 2007 8:53 pm
by Trace
could you rehost the photo please? looks like i'm having some leaking problem as well ...
Posted: Tue Aug 26, 2008 6:20 pm
by TrueBlue
I have this exact same problem - grabbed a shot of it last night. A PO tried patching it with fiberglass but it's unsuccessful. I've pushed aside the plastic cover, also caked with dirt.
Hope that helps someone out.
Any other place to grab one besides a dealership or am I looking at a repair / parts hunt?
Posted: Tue Aug 26, 2008 6:24 pm
by Legacy777
You could try a junkyard. Otherwise, I'd probably look at the dealer or online subaru parts store.
Posted: Tue Aug 26, 2008 7:08 pm
by TrueBlue
nubs said he dug one up five years ago at $150, but further searching (

) here netted this:
http://www.supermotors.net/getfile/6663 ... r_neck.jpg
$113. Best price I've found, and it's not on rockauto.com.
Re: Potential fuel leak problem all BC-BF owners
Posted: Mon May 19, 2014 1:17 pm
by silver03
I suspect our 94 may be leaking at the neck. Anyone know the interchangeability between legacy years? Theres one for sale locally on CL new for a 97. Wagon or sedan specific? thank you as usual.
Re: Potential fuel leak problem all BC-BF owners
Posted: Mon May 26, 2014 3:28 am
by Legacy777
Unfortunately, the newer Legacy fuel filler necks do not fit. Any of the first gen 90-94 Legacy fuel fillers should be interchangable. No difference between wagon and sedan.