3 pics of the AWIC setup
Moderators: Helpinators, Moderators
Re: 3 pics of the AWIC setup
you can use this one...
OPEL, CORSA A CC (93_, 94_, 98_, 99_), Baujahr: 09/82-03/93
33 KW (45 PS), 986 ccm, 4 Zylinder
but this radiator is smaller then Corsa B 1,0 Radiator which i used for the awic.
OPEL, CORSA A CC (93_, 94_, 98_, 99_), Baujahr: 09/82-03/93
33 KW (45 PS), 986 ccm, 4 Zylinder
but this radiator is smaller then Corsa B 1,0 Radiator which i used for the awic.
Subaru...Bolt on Power!
Re: 3 pics of the AWIC setup
dscoobydoo wrote:Ok, after running this for a few days, my temp gauge is definately seeing the effects of the AWIC in front.
The gauge is reading about 2/3 up ( compared to halfway before)
anyone else experience this with a AWIC>?
It shouldn't have gone up that much, or so I would think. How thick was the AWIC exchanger again?
I did not notice any change in the engine temp gauge when I put my exchangers on. The only thing I did notice was that the fans will run a little longer/faster with the AC during the summer. There's a secondary switch in the AC pressure switch on the drier that is causing this due to the higher pressures likely caused be not enough cooling. This only happens in the summer during the day. At night, I don't notice this.
Josh
surrealmirage.com/subaru
1990 Legacy (AWD, 6MT, & EJ22T Swap)
2020 Outback Limted XT
If you need to get a hold of me please email me rather then pm
surrealmirage.com/subaru
1990 Legacy (AWD, 6MT, & EJ22T Swap)
2020 Outback Limted XT
If you need to get a hold of me please email me rather then pm
-
- Fifth Gear
- Posts: 2275
- Joined: Mon Mar 08, 2004 2:30 am
- Location: Auburn, WA
- Contact:
Re: 3 pics of the AWIC setup
OK, I figured out what is up, and it's not the AWIC.
Yes I have too many Subarus
No you can't have one
05 GD-STI
01- RS- Swapped-07 STI
00- GF
93 SS- "the original Robtune" (now in new hands)
No you can't have one
05 GD-STI
01- RS- Swapped-07 STI
00- GF
93 SS- "the original Robtune" (now in new hands)
Re: 3 pics of the AWIC setup
What was the problem?
Josh
surrealmirage.com/subaru
1990 Legacy (AWD, 6MT, & EJ22T Swap)
2020 Outback Limted XT
If you need to get a hold of me please email me rather then pm
surrealmirage.com/subaru
1990 Legacy (AWD, 6MT, & EJ22T Swap)
2020 Outback Limted XT
If you need to get a hold of me please email me rather then pm
Re: 3 pics of the AWIC setup
You must modify your AWIC Waterpump.
The Pump output is normally low (28watts) when the ignitions switch is ON, and changed to high (50 watts)
when the throttle opening exceeds 80% as shown below.
the original waterpump is very good.
15l/min or 4,0 US gal. / min
50W high
20W low
you must modify the waterpump, that the waterpump only pumps in high Mode with 50W
so the water would be recirculate faster and the water is coolder.
The Pump output is normally low (28watts) when the ignitions switch is ON, and changed to high (50 watts)
when the throttle opening exceeds 80% as shown below.
the original waterpump is very good.
15l/min or 4,0 US gal. / min
50W high
20W low
you must modify the waterpump, that the waterpump only pumps in high Mode with 50W
so the water would be recirculate faster and the water is coolder.
Subaru...Bolt on Power!
-
- Fifth Gear
- Posts: 2275
- Joined: Mon Mar 08, 2004 2:30 am
- Location: Auburn, WA
- Contact:
Re: 3 pics of the AWIC setup
My pump is one from a Ford Mustang/lightning with an AWIC, and it only has one mode.
Here in the US, we never had the AWIC, so everything we do is custom.
Here in the US, we never had the AWIC, so everything we do is custom.
Yes I have too many Subarus
No you can't have one
05 GD-STI
01- RS- Swapped-07 STI
00- GF
93 SS- "the original Robtune" (now in new hands)
No you can't have one
05 GD-STI
01- RS- Swapped-07 STI
00- GF
93 SS- "the original Robtune" (now in new hands)
-
- First Gear
- Posts: 80
- Joined: Sat Dec 30, 2006 4:03 am
- Location: New Zealand
Re: 3 pics of the AWIC setup
Hey I can get my hands on a radiator from a Corsa B 1.4l. Do you know if they are the same or even remotely close to the 1.0 radiators?legT91 wrote:you can use this one...
OPEL, CORSA A CC (93_, 94_, 98_, 99_), Baujahr: 09/82-03/93
33 KW (45 PS), 986 ccm, 4 Zylinder
but this radiator is smaller then Corsa B 1,0 Radiator which i used for the awic.
1990 Legacy GT wagon. 100% JDM, 100% factory.
Re: 3 pics of the AWIC setup
+1Legacy777 wrote:What was the problem?
How did you fix it?
Turbo Subies:
'87 GL-10 Turbo - SOLD
'90 BJ EJ22T/DOHC & 5speed swap - SOLD
'04 FXT, Forged internals, VF39, STI TMIC, Cobb AP- SOLD
'93 Legacy SS - 5-speed, SOLD :-(
'02 WRX -SOLD
'96 BD-turbo'd-SOLD
'98 SF - NA-T
'87 GL-10 Turbo - SOLD
'90 BJ EJ22T/DOHC & 5speed swap - SOLD
'04 FXT, Forged internals, VF39, STI TMIC, Cobb AP- SOLD
'93 Legacy SS - 5-speed, SOLD :-(
'02 WRX -SOLD
'96 BD-turbo'd-SOLD
'98 SF - NA-T
-
- Fifth Gear
- Posts: 2275
- Joined: Mon Mar 08, 2004 2:30 am
- Location: Auburn, WA
- Contact:
Re: 3 pics of the AWIC setup
Dash cluster had issues. New cluster, no issues.
Yes I have too many Subarus
No you can't have one
05 GD-STI
01- RS- Swapped-07 STI
00- GF
93 SS- "the original Robtune" (now in new hands)
No you can't have one
05 GD-STI
01- RS- Swapped-07 STI
00- GF
93 SS- "the original Robtune" (now in new hands)
-
- Second Gear
- Posts: 322
- Joined: Sat Mar 03, 2007 8:10 am
- Location: arvada co
Re: 3 pics of the AWIC setup
this thread kinda makes me want to redo my awic heat exchanger. I just put a 91 talon tsi a/c condenser in,as a cooler core its a little tight between the frame and radiator but its the same length as the radiator but a tad bit smaller in height.
I have noticed the awic core is running a lot cooler, the pump I'm running is a shure flow 40psi. 2.8gpm diaphragm pump,
awic coolers can be ran with a vf-11 you will have to put a 45 degree tube between the turbo outlet and the awic j pipe.
I have noticed the awic core is running a lot cooler, the pump I'm running is a shure flow 40psi. 2.8gpm diaphragm pump,
awic coolers can be ran with a vf-11 you will have to put a 45 degree tube between the turbo outlet and the awic j pipe.
91 SS, v9 ej207 twin scroll swap, Gda wrx dash swap.
2002 wrx sport wagon
2002 wrx sport wagon
Re: 3 pics of the AWIC setup
my legacy must be the same as yours then LegT91. i have a wagon. imported from germany in 05, up to norway. it was in pretty good shape. do you salt your roads down there? we are heavy on it
one thing ive been pondering on. how do you troubleshoot your awic? cant find anything on the net. if something on it isnt working, how would one know? looking at the boost only? knocking?
one thing ive been pondering on. how do you troubleshoot your awic? cant find anything on the net. if something on it isnt working, how would one know? looking at the boost only? knocking?
1992 wagon ej20g