2.5 DOHC Timing Belt issue

Heads, valves, pistons, rods, crankshaft, etc...

Moderators: Helpinators, Moderators

Post Reply
georryan
Fourth Gear
Posts: 2097
Joined: Thu Oct 17, 2002 1:39 am
Location: USA Bellingham WA

2.5 DOHC Timing Belt issue

Post by georryan »

I know this isn't the right bbs for this engine, but there are good people on this BBS with knowledge of these engines as well. If the moderators would prefer I take it somewhere else, feel free to drop this post and PM me that you've done so, thanks.

I have a relative that has a 96 outback, 2.5 dohc. He was driving home from work and from my estimate, his water pump seized up, the round cylinder on the water pump that the timing belt spins actually came through the front plastic cover, and then the timing belt slipped some teeth and the car stopped.

My guess is that at least a couple bent valves are a near given. My relative is incredibly strapped for cash at the moment and I've offered to do the work, or at least as much as I can. What would be the best way to go about handling and diagnosing this, or would it be better to just purchase a used longblock off of ebay or some such place for under 1k?

Can I check for bent valves without pulling the heads? Will there be a clear indication on the rocker assembly after removing the valve covers?

Thanks for any input you guys may have!
91 Pearl White Sport Sedan
04 Java Black Pearl Forester XT
2014 Volvo S60 T5
18 KTM 1290 Adventure S

87 Grey GL-10 Sedan (so long old buddy) - donated
97 Toyota 4Runner SR5 - sold
2002 BMW r1150rt-p - sold
2004 BMW r1200ST - sold
2016 BMW r1200RS - sold
martimus919
First Gear
Posts: 222
Joined: Sat Sep 19, 2009 6:21 am
Location: Reno, NV

Re: 2.5 DOHC Timing Belt issue

Post by martimus919 »

I'd start with getting a new timing belt kit with water pump of course, and putting it on. It's the easiest way to see if it has bent valves. I've actually picked up a few Outbacks that had the timing belt go due to the geared pulley exploding and all I did was put a timing belt on and they worked great.
07 Outback XT VF52
94 Legacy Sport, VF23, 550 RobTune, various other things
93 Legacy Touring Wagon EJ205 management and dash swap (in progress)
90 Loyale Turbo, EJ Turbo Swap, 2" lift
82 Brat, EJ22 swap, RX AWD trans w/ LSD rear, 5 lug 4 wheel disc.
PhyrraM
Fourth Gear
Posts: 1980
Joined: Thu Aug 11, 2005 4:34 pm
Location: Lake Elsinore, CA

Re: 2.5 DOHC Timing Belt issue

Post by PhyrraM »

If you have access to an air compressor you can do a leakdown test on the cylinders without a timing belt installed to check for bent valves.
'93 Winestone SS Auto, '91 Pearl White SS.
'93 Pure White SS EJ20G slanty intercooled, SIDESWIPED! In stasis.
'94 FWD and '95 AWD Laguna Blue SVXs.
2017 Pure Red BRZ Limited w/Performance pack
Legacy777
Site Admin
Site Admin
Posts: 27931
Joined: Tue Oct 15, 2002 11:37 am
Location: Houston, Tx
Contact:

Re: 2.5 DOHC Timing Belt issue

Post by Legacy777 »

Yeah I'd suggest a leak down test as well. That's going to be your best indication without spending money you don't need to.
Josh

surrealmirage.com/subaru
1990 Legacy (AWD, 6MT, & EJ22T Swap)
2020 Outback Limted XT

If you need to get a hold of me please email me rather then pm
mike-tracy
Moderator
Moderator
Posts: 5000
Joined: Tue Aug 25, 2009 7:52 am
Location: Des Moines, Wa

Re: 2.5 DOHC Timing Belt issue

Post by mike-tracy »

If the old belt is intact, personally I'd use it during the diagnosis, and then buy a new one if everything checks out. Unless it got stretched I suppose :(
1992 Legacy SS 5mt, build in progress
Josh Colombo wrote: Mon Jan 14, 2002 10:23 am Wait....I'm confused now.
wtdash
Fifth Gear
Posts: 2349
Joined: Fri May 04, 2007 4:09 pm
Location: N. ID

Re: 2.5 DOHC Timing Belt issue

Post by wtdash »

Hi,
The EJ22 from a '95 Legacy w/the EGR (Automatic) is a 99% drop in and they are a lot less than the 2.5 (since the 2.5 fails so often = high demand). ...Usually $500. You can use a newer '96-98 EJ22, but will need the y-pipe as they are single-port exhaust vs. the dualies on the 2.5....just ensure any EJ22 has the EGR or it'll throw a CEL.

The USMB has a bunch of info on the swap if it comes to that....I've done a couple - easy/peasy.

GL,
Td
Turbo Subies:
'87 GL-10 Turbo - SOLD
'90 BJ EJ22T/DOHC & 5speed swap - SOLD
'04 FXT, Forged internals, VF39, STI TMIC, Cobb AP- SOLD
'93 Legacy SS - 5-speed, SOLD :-(
'02 WRX -SOLD
'96 BD-turbo'd-SOLD
'98 SF - NA-T
Post Reply